Jump to content

Leaderboard

Popular Content

Showing content with the highest reputation on 01/10/18 in all areas

  1. Hi Kogers, I have done a lot of research into the diesel heater . I pulled mine out after it started to smoke on start up and found that the problem was the breather hole near the glow plug was starting to block up , just like in a combustion engine when you stop the air flow they smoke from to much fuel . I also found that after doing the corner country trip this year without the air intake blocked ( to stop the diesel heater getting dust in) when I pulled it apart , no dust . I will not be going to the trouble to block mine anymore . To service your heater all you need to buy is a gasket seal the 3rd on the parts list . There is no need for a special tool to pull your glow plug ( glow pin ) out , just pull the unit apart and then a 12 m spanner will do the job . With the unit striped down a piece of wire to clean the hole that is just at the top of the screen as show on page 28 of the service book . I have attached a service book ( I hope ) airtronic service book.pdf With the unit out of the van you can have it cleaned and back together in 30 minutes . Cheers Nev
    1 point
×
×
  • Create New...